Product ID:PYRO CHEM REGULAR-STEARATEDED BC
MSDS Date:02/01/1993
FSC:4210
NIIN:00-889-2221
MSDS Number: BXNYB

PYRO-CHEM INC

301 DIVISION ST
BOONTON, NJ 07005-1826
US

Emergency Phone: 201-335-9750

Info Phone: 201-335-9750

Cage: 4J390

PYRO-CHEM INC

BOONTON, NJ 07005-1826 US

Telephone: 201-335-9750

Cage: 4J390

SODIUM BICARBONATE

CAS: 144-55-8

RTECS: VZ0950000

Fraction By Weight: 86-92%

ACGIH TLV: 15 MG/CUM

SILICA, MICA, MUSCOVITE

CAS: 12001-26-2

RTECS: VV8760000

Fraction By Weight: 1-3%

OSHA PEL 20 PPM

ACGIH TLV: 3 MG/CUM

MAGNESIUM ALUMINUM SILICATE *95-1*

CAS: 8031-18-3

Fraction By Weight: 1-3%

ACGIH TLV: 10 MG/CUM

SILICON DIOXIDE, CELITE 322

CAS: 112945-52-5

RTECS: VV7310000

Fraction By Weight: 0.5-2.5%

OSHA PEL 80 MG/CUM

ACGIH TLV: 0.2 MG/CUM

MAGNESIUM STEARATE

CAS: 557-04-0

RTECS: WI4390000

Fraction By Weight: 0.5-2%

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE IRRITATION OF
NOSE & THROAT. EYES: MAY CAUSE IRRITATION. SKIN: MAY CAUSE
SLIGHT-SEVERE IRRITATION.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, COUGHING, CHEST DISCOMFORT.
Medical Cond Aggravated by Exposure:RESPIRATORY DISEASE, ASTHMA,
EMPHYSEMA, SKIN SENSITIVITY.

First Aid:EYES: FLUSH THOROUGHLY W/WATER FOR 15 MINS. SKIN: WASH W/SOAP
& WATER. INHALATION: REMOVE TO FRESH AIR. GIVE CPR IF NEEDED.
INGESTION: IF >1 PINT IS INGESTED, IMMEDIATELY GIVE 1-2 GLASSES OF
WATER. DO N'T INDUCE VOMITING/GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. OBTAIN MEDICAL ATTENTION IN ALL CASES. NOTES TO
PHYSICIAN: SYMPTOMATIC TREATMENT ONLY.

Fire Fighting Procedures:WEAR SCBA. PREVENT RUNOFF FROM FIRE
CONTROL/DILUTION FROM ENTERING STREAMS/DRINKING WATER SUPPLY. USE
STANDARD CHEMICAL FIRE FIGHTING PROCEDURES. (SEE SUPP)
Unusual Fire/Explosion Hazard:NONE

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT/RUBBER
BOOTS/GLOVES/APRON & FULL FACE PIECE/HALF MASK AIR-PURIFYING
CARTRIDGE RESPIRATOR W/PARTICULATE FILTERS/CHEMICAL GOGGLES IF A
HALF MASK IS WORN. SMALL: SWEEP UP & DISP OSE OF IN DOT APPROVED
WASTE CONTAINER.(SEE SUPP)

Handling and Storage Precautions:STORE IN A COOL, DRY, WELL VENTILATED
PLACE AWAY FROM ACIDIC & AMMONIUM COMPOUNDS. KEEP BAGS/FIBER DRUMS
DRY AT ALL TIMES.
Other Precautions:DON'T GET IN EYES, ON SKIN/CLOTHING. DON'T
CUT/GRIND/DRILL ON/NEAR PRODUCT CONTAINERS. EMPTY CONTAINERS CAN
HAVE RESIDUES/GASES/MISTS & SHOULD BE HANDLED AS IF THEY WERE FULL.

Respiratory Protection:WEAR A NIOSH/MSHA APPROVED DUST RESPIRATOR FOR
DUSTY CONDITIONS/IF DUST LEVELS EXCEED ESTABLISHED STANDARDS.
Protective Gloves:RUBBER
Eye Protection:CHEMICAL GOGGLES
Other Protective Equipment:RUBBER BOOTS/APRON
Work Hygienic Practices:GOOD PERSONAL HYGIENE PRACTICES SHOULD ALWAYS
BE FOLLOWED. WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
SPECIAL FIRE CONT'D: CONSIDER HAZARDS OF OTHER INVOLVED MATERIALS.
SPILLS CONT'D: LARGE: SHOVEL INTO DOT APPROVED WASTE CONTAINERS.
KEEP OUT OF SEWERS/STORM DRAINS/SURFACE WATERS & SOIL.

Solubility in Water:LIMITED
Appearance and Odor:FINE WHITE POWDER W/NO ODOR.

Stability Indicator/Materials to Avoid:YES
ACIDIC & AMMONIUM COMPOUNDS.
Stability Condition to Avoid:EXTREME HEAT.
Hazardous Decomposition Products:CO2 & AMMONIA GAS.

Waste Disposal Methods:DISPOSE OF CONTAMINATED PRODUCT & MATERIALS USED
IN CLEANING UP SPILLS/LEAKS IAW/FEDERAL, STATE & LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.